Home Science & Technology FAA orders airlines to replace Boeing cockpit display units

FAA orders airlines to replace Boeing cockpit display units

The Federal Aviation Administration (FAA) has ordered airlines to replace or modify the cockpit display units fitted to hundreds of Boeing jets.

The US air safety regulator said that tests had indicated that mobile phone and computer signals could cause the screens to go blank.

The affected planes are typically fitted with several screens, each of which costs thousands of pounds.

Honeywell – the displays’ manufacturer – has stressed that the problem has not been experienced in-flight.

“The only known occurrence was during a developmental test conducted on the ground,” said spokesman Steve Brecken.

“We worked with Boeing and addressed any concerns in 2012 with new display hardware.”

Boeing had previously issued an alert in November 2012 after an aero plane operator and Wi-Fi vendor noticed interference caused by the installation of an in-flight internet system.

The “phase 3” display units were found to be susceptible to the same radio frequencies used to transmit data via Wi-Fi.

The FAA has ordered airlines to replace or modify the cockpit display units fitted to hundreds of Boeing jets

The FAA has ordered airlines to replace or modify the cockpit display units fitted to hundreds of Boeing jets

In addition, the FAA said it was concerned that the screens could be disrupted by mobile satellite communications, cellular signals from phones, and air surveillance and weather radar.

The watchdog noted that the displays were required to provide pilots with information about airspeed, altitude, heading and pitch and roll, and added that the fault could cause a crash.

“We are issuing this AD [airworthiness directive] to prevent loss of flight-critical information displayed to the flight crew during a critical phase of flight, such as an approach or take-off, which could result in loss of airplane control at an altitude insufficient for recovery, or controlled flight into terrain,” it said.

Planemaker Boeing said that it had recommended that carriers implement the changes back in 2012.

However, the FAA said that it had estimated that a total of 1,326 Boeing 737 and 777 jets still needed to make the change.

It estimated that the replacement program would cost about $13.8m (£8.5m) to implement.

The agency noted that Virgin Australia, Air France, Ryanair and Honeywell were among those that had opposed the new rules on the grounds that they did not believe either current in-flight Wi-Fi systems or passengers’ electronic devices emitted signals at a strong enough level to affect equipment on the flight deck.

The FAA said Ryanair had complained that the demands imposed “a high, and unnecessary, financial burden on operators”.

Honeywell had suggested that airlines should be forced to install new screens only if Wi-Fi enabled tablets or other such equipment were used in the cockpit.

However, the FAA rejected these complaints saying it wanted to “eliminate” any risk of interference.

“We do not agree that no problems have occurred on in-service airplanes, since the Wi-Fi… testing that disclosed this susceptibility was conducted on an in-service airplane fitted with phase 3 display units,” it added.

The FAA has given the companies involved five years to swap or modify the components.

Experts said the public should not be alarmed.

Clyde is a business graduate interested in writing about latest news in politics and business. He enjoys writing and is about to publish his first book. He’s a pet lover and likes to spend time with family. When the time allows he likes to go fishing waiting for the muse to come.